Product ID:84906 RED (M-6) MARKER BASE
MSDS Date:07/12/1996
FSC:7510
NIIN:00F036680
MSDS Number: CCZMT

ITW FLUID PRODUCTS GROUP

8501 DELPORT DRIVE
ST LOUIS, MO 62114-5000
US

Emergency Phone: 800-443-9536

Info Phone: 800-443-9536

Preparer: LAKS RAMACHANDRAN

Cage: ITWFL

ITW FLUID PRODUCTS GROUP

UNKNOW ST LOUIS, MO 63114 US

Telephone: 800-443-9536

Cage: ITWWW

ISOBORNYL METHACRYLATE, METHACRYLIC ACID, METHYL

CAS: 38414-49-2

Fraction By Weight: 1-10%

ALKYD RESIN

Fraction By Weight: 8-15%

TITANIUM DIOXIDE PIGMENT

CAS: 62338-64-1

Fraction By Weight: 1-10%

RED PIGMENT 48 *96-4*

CAS: 5280-66-0

Fraction By Weight: 1-10%

COATING, MATERIAL 7.42 LB/GAL

RTECS: 9999999VO

PROPYLENEGLYCOL MONOMETHYL ETHER ACETATE,

CAS: 108-65-6

RTECS: AI8925000

Fraction By Weight: 11-30%

XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *96-4*

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 51-70%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM, SKIN

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

LD50 LC50 Mixture:ORAL LD50(RAT): 10000 MG/KG (SEE SUPP)
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF THE
RESPIRATORY TRACT. EYES: MODERATE IRRITATION. SKIN: MODERATE
IRRITATION, SENSITIZATION & DERMATITIS. INGESTION: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, NAUSEA,
VOMITING.
Medical Cond Aggravated by Exposure:SKIN & RESPIRATORY DISORDERS.

First Aid:EYES: FLUSH WELL W/WATER. SKIN: WASH W/SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN. INGESTION: DON'T
INDUCE VOMITING. IF VOMITING OCCURS, KEEP HEAD BELOW HIPS TO
PREVENT ASPIRATION OF L IQUID INTO LUNGS. OBTAIN MEDICAL ATTENTION
IN ALL CASES.

Flash Point Method:TCC
Flash Point:81F
Lower Limits:1.3
Upper Limits:13.1
Extinguishing Media:CO2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:DON'T USE WATER/ALCOHOL FOAM. WEAR SCBA IN
CONFINED AREAS.
Unusual Fire/Explosion Hazard:VAPORS ARE > AIR & MAY TRAVEL ALONG
GROUND/BE MOVED BY VENTILATION & IGNITE BY IGNITION SOURCE.
IGNITION MAY OCCUR AT TEMPS < AUTOIGNITION/IGNITION TEMPS.(SUPP)

Spill Release Procedures:PREVEN SKIN & EYE CONTACT. USE NON-COMBUSTIBLE
MATERIAL TO CONFINE &/ABSORB. ELIMINATE IGNITION SOURCES. VENTILATE
AREA.

Handling and Storage Precautions:DON'T PRESSURIZE, CUT, WELD, BRAZE,
SOLDER, DRILL, GRIND/EXPOSE CONTAINERS TO HEAT, SPARKS, FLAMES,
STATIC ELECTRICITY/OTHER SOURCES OF IGNITION.
Other Precautions:USE W/ADEQUATE VENTILATION. EMPTY CONTAINERS RETAIN
RESIDUE & CAN BE DANGEROUS. ANY PROPOSED USE OF THIS PRODUCT IN
ELEVATED TEMPS SHOULD BE THOROUGHLY EVALUATED TO ASSURE SAFE
OPERATING CONDITIONS & MAINTAIN.

Respiratory Protection:IN POORLY VENTILATED AREAS, USE NIOSH APPROVED
ORGANIC VAPOR RESPIRATOR.
Ventilation:LOCAL EXHAUST FOR CONFINED AREAS. MECHANICAL (GENERAL) FOR
NORMAL USE.
Protective Gloves:CHEMICAL RESISTANT RUBBER
Eye Protection:SAFETY GLASSSES W/SPLASH PROOF GOGGLES
Other Protective Equipment:POLYVINYL CHLORIDE-COATED, PROTECTIVE GEAR,
PROTECTIVE CLOTHING/EQUIPMENT, EYE BATH, SAFETY SHOWER.
Supplemental Safety and Health
FIRE HZRD CONT'D: MANY HOT ORGANIC CHEMICAL VAPORS/MISTS ARE
SUSCEPTIBLE TO SPONTANEOUS COMBUSTION WHEN MIXED W/AIR. IGNITION
TEMPS DECREASE W/INCREASING VAPOR VOLUME & VAPOR/AIR CONTACT TIME &
ARE IN FLUENCED BY PRESSURE CHANGES. IGNITION OF ORGANIC CHEMCIAL
VAPORS MAY OCCUR AT TYPICAL ELEVATED TEMPS.

Boiling Pt:B.P. Text:282-302F
Vapor Pres:14
Vapor Density:>1
Spec Gravity:0.91
Evaporation Rate & Reference:(BU AC = 1): >1
Solubility in Water:APPRECIABLE
Appearance and Odor:RED OPAQUE LOW VISCOSITY LIQUID W/SWEET SOLVENT
ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAMES.
Hazardous Decomposition Products:OXIDES OF CARBON.

Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. HAZARDOUS WASTE CODES: D001 (IGNITABILITY); U031
(BUTYL ALCOHOL). PAINT, 3, UN1263.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.